The last of American flag passengers ships…
A home video of a trip aboard the “SS Santa Maria” taken in 1983. This was one of four cargo-passenger ships built by the Grace Line in 1964 and operated by Delta Lines in the 1970s and early 1980s. These ships were often called the “M” ships.
The first class cargo-passenger ships sailed from the West Coast around South America.
This video is of sailing from Los Angeles to San Francisco about a year before the four ships were taken out of service. Toward the end of the video, a sister ship, the “Santa Mercedes”, is shown. It had been recently taken out of service. It is the only one of the ships that survived the breakers. It became the training ship for the Massachusetts Maritime Academy and named the “Patriot State”…
GRACE LINE HISTORY…
Dining Room aboard the all first class Grace Line ships in the 1930s featuring “dining under the stars”…
Dining under the stars was featured on Grace Line ships from East and West Coast ports to the Caribbean and South America via the Panama Canal during the 1930s until the cruise liners were replaced in the 1950s.
The dining room on each of four sister ships were located on upper decks (bad in rough weather) and featured wide casement windows, which opened onto the promenade decks.
The dining room ceilings rolled back so passengers could dine under the stars. The night sky and the ship’s funnel can be seen in the above photo from a late 1930s advertisement.
Classical elegance is the keynote here, while the painting of a sailing vessel adds a discreet maritime touch.
SS SANTA ROSA in Los Angeles Harbor, California – 1936.
The SS Santa Rosa was one of four sister ships — the Santa Rosa Class — featuring “dining under the stars” aboard Grace Line cruises to the Caribbean, South America and Mexico via the Panama Canal.
1928 Grace Line advertisement – $250 and up First Class – 18 Days to Peru – appearing in Travel Magazine
These “Santa” ships had some general resemblance to Matson Line’s MALOLO, with her great beam and low stern. Their original gross tonnage of 11,200 was later reduced to 9,100 by the cutting of tonnage openings in # 6 shelter deck. Subsequently their tonnage was again changed, all of which reduced tonnage dues and Panama Canal tolls. Their overall length was 508 ft. and beam 72 ft. Their power plants were at the time second to none in efficiency. Each of the water tube steam generators with a pressure of 430 lbs. produced 6000 hp. and each ship could make 18-1/2 knots with only three boilers active. The main engines were double reduction turbines. The screws turned inward, and for this reason were very awkward to maneuver.
The passenger capacity of the SANTA ROSA class was 209 in first class and about 50 in steerage. Their public rooms were all on the promenade deck, with the dining salon extending two and a half decks in height to a roll back dome. The after dining room bulkhead was adorned with a large oil painting of a Grace clipper. Each cabin, whether single or double was equipped with private bath.
W. R. Grace and Co. was founded in Peru in the mid-19th century by the Irish-born Grace brothers, William Russel and Michael, to engage in the guano trade.
The Grace brothers prospered, especially in the exporting of guano from the Chincha Islands to the United States, where this fertilizer as in considerable demand using sailing ships.
1928 Grace Line advertisement appearing in Travel Magazine
In 1865, leaving Michael in charge of their interests in Callao, William established the firm of W.R. Grace & Co., in New York. By 1880 he had become a leading citizen and was twice elected Mayor of New York, despite opposition from Tammany. In the 1880’s the company entered the steamship business with a line of freighters running from New York to the South American west coast via the Strait of Magellan flying the British flag. What later became the Grace Line originated in 1882 as a line of sailing vessels between Peru and New York.
Grace’s original British-flag ships had black hulls, white painted masts and booms, and a green stack with a black top. After the First World War successors were painted grey, with masts and booms of the usual mast color. Hulls became black again in 1928 and masts and booms reverted to white in 1932. (about 1959-60 Grace passenger ships again turned to grey hulls).
The early British-flag freighters all had names beginning with C, such as CACIQUE, CAPAC, CHINCHA; Names which were later repeated in ships under the American flag.
Later Grace started a service from the Pacific coast of the United States to the west coast of South America, and in 1913 took delivery of the 4,826 gross ton, 400-foot Santa Cruz from William Cramp & Sons of Philadelphia for this run. She was their first American flag ship and was especially designed to carry a large deckload of lumber, as well as 48 passengers. three boilers provided steam for a 2400 horsepower triple expansion engine, which gave her a speed of 11-12 knots. She introduced the green funnel with white band and black top, which continued to be the Grace stack, colors.
Grace established regular steamship service in 1893 with a subsidiary called the New York & Pacific Steamship Co., operating under the British flag because ships built outside the United States were banned from US registry until 1905. US-flag service began in 1912 with the Atlantic and Pacific Steamship Company. The activities of both companies and the parent firm were consolidated into the Grace Steamship Company beginning in 1916. The firm originally specialized in traffic to the west coast of South America; then expanded into the Caribbean.
COLUSA, of 5873 gross tons and 424 feet, was also built in 1913, by Hamilton of Port Glasgow, Scotland, for the same service as the SANTA CRUZ. She was Grace’s last ship for British-flag operations. Three boilers and a quadruple expansion engine of 3500 horsepower gave her a service speed of 12 knots. She too, was built to carry large loads of lumber on deck. She had four masts at first, but was later given a fifth with a 100 ton boom, and handled fully assembled steam locomotives for the South American ports. Her 36 passenger capacity was later increased to 50.
In 1914 COLUSA was transferred to the U.S. flag and was renamed Santa Cecelia (a misspelling of CECILIA). Some of the British-flag ships were lost by enemy action, and only two were left at the end of the first world war. Grace also operated a cargo service from Seattle to Chile with way calls along the coast.
To restore Transpacific service, Grace bought in 1915 three ships under construction in Holland; Colombia, Ecuador and Venezuela, laid down for the Royal Netherlands West India Mail, these had been intended to run down to the west coast of South America via the Panama Canal, but had been sold on the stocks to the Norwegian owner Chr. Hannevig, who proposed to use them between New York and the South American east coast, a run discontinued by Lamport and Holt and Booth Line because of the war. Hannevig, however accepted Grace’s offer to buy the ships before they were completed. Colombia kept her name until she was lost. This unlucky ship first ran aground on Cano Island off Costa Rica in 1923, remaining there two months. Practically her whole bottom had to be removed in drydock at Balboa. In the fall of 1931 she went to her grave on the south end of Margarita Island off lower California. Venezuela struck a mine on the way out from Holland and was repaired in England.
In 1916 Grace decided to institute a passenger service from New York to ports on the west coast of South America as far as Valparaiso, Chile, and contracted for five ships; SANTA ANA, SANTA LUISA, SANTA TERESA (By Cramp) and SANTA ELISA and SANTA LEONORA (by New York Shipbuilding). These 110 passenger ships were 376 feet long with a gross tonnage of 5800. They had four boilers each and quadruple sxpansion engine of 3300 hp. in the Cramp ships and 3400 in the others. Their service speed of 13 knots could be exceeded by a knot.
The United States Shipping Board took these five ships over for transport duty. By the time the troops had been carried back from France, Grace had decided that four would be sufficient for the intended service, and declined return of the SANTA LEONORA, which went to the Navy and became the submarine tender CANOPUS, ultimately lost in the Philipines early in 1942. In 1926 the secondary service from New York as far as Antofagasta, Chile was begun with the SANTA CRUZ, which was joined in the following year by SANTA CECI(E)?LIA ( ex COLUSA)
Also in 1916, the company acquired a controlling interest in the venerable Pacific Mail Steamship Company, premier west coast and transpacific operator, which had already sold its big ships and retained only the lesser vessels of the Central American service.
In 1921 the Shipping Board allocated five 535 ft. President class ships for Transpacific operation by Pacific Mail Line. these were PRESIDENT CLEVELAND, (ex GOLDEN STATE), PRESIDENT LINCOLN (ex HOOSIER STATE), PRESIDENT PIERCE (ex HAWKEYE STATE), PRESIDENT TAFT (ex BUCKEYE STATE) and PRESIDENT WILSON (ex EMPIRE STATE).
COLOMBIA, ECUADOR and VENEZUELA were thus displaced and in the following year were transferred from the far east run to the intercostal run. At the same time Grace placed on the same run the freighters SANTA BARBARA, SANTA CLARA, SANTA MALTA, SANTA OLIVIA, SANTA PAULA and SANTA ROSA. These six , making connection with the President ships at San Francisco, provided fast freight service from Atlantic ports to the far east.
In 1923 the Shipping Board invited bids for the sale of the President ships operated by Pacific Mail. The Dollar Line outbid Grace and was awarded the vessels. Finding itself without ships suitable for the transpacific trade, Pacific Mail sold its registered name and goodwill to Dollar. Grace now without a transpacific connecting service, had no further use for the six inter-costal freighters and sold them off to the American Hawaiian Line.
At this time Grace formed a new entity, the Panama Mail Company, to operate the small ships formerly owned and used by the Pacific Mail in the Central American trade, these ships not having been involved in the sale to Dollar. COLOMBIA, ECUADOR and VENEZUELA also remained under Grace Ownership.
In 1928 to meet competition from the Pacific Steam Navigation Company and the Chilean Line, Grace took delivery of SANTA BARBARA and SANTA MARIA, which were a great improvement over previous ships. As it was then permissible to build ships in foreign countries for U.S. flag operation and retain eligibility for mail contracts, the Furness Shipbuilding Company in Haverton-on-Tees, England, constructed these sisters. Each had two 8-cylinder, 2 cycle Sulzer diesel engines of 4000 hp. apiece. They were the first large motor passenger ships to sail under the U.S. flag.
The service speed of these 150 passenger vessels was 16 knots, their overall length 480 ft. and their gross tonnage 8000. In later years , after the advent of the 18 knot SANTA CLARA, a project for increasing the speed of these ships was considered. It was proposed to install a third 4000 hp. diesel engine which would transmit power to the two propeller shafts through a generator and two electric motors. In view of their somewhat old-style passenger accommodations, however, these plans did not materialize.
Since only four ships were required for the Valparaiso service, SANTA ANA and SANTA LUISA were transferred to the Panama Mail’s New York-San Francisco run and were renamed respectively GUATEMALA and EL SALVADOR.
In 1929 SANTA INEZ and SANTA RITA joined the fleet. Apart from cruiser stern, short funnel and diesel propulsion, these ships built by Burmeister & Wain of Copenhagen, were much like the SANTA ANA class. Measuring 5000 tons and 386 ft. overall, they had accommodations for 125 passengers in two classes. Each had two six cylinder, 4 cycle, 3600 HP main engines, giving a service speed of 13 knots. SANTA RITA made 15.1 on her trials. This pain joined SANTA CECILIA and SANTA CRUZ in Grace’s secondary service which was now extended to Valparaiso.
When SANTA CLARA was added in 1930, it was decided to speed up the schedule, thus rendering superfluous SANTA ELISA and SANTA TERESA which entered the secondary service. Replacing SANTA CECILIA and SANTA CRUZ. From the New York Shipbuilding Corporation, SANTA CLARA was a larger SANTA BARBARA, 20 ft. longer, two knots faster, and about the same tonnage. Her propulsion was quite different, however, two turboelectric units with a combined output of 12,000 hp. The service that had required four ships was reduced to three. SANTA BARBARA and SANTA MARIA had to do their utmost to maintain the schedule that called for about 17 knots.
Upon COLOMBIA’S loss in 1931, the Grace ships SANTA ELISA and SANTA TERESA were transferred to Panama Mail, in order to have four vessels of the same capacity and speed on the New York San Francisco run. ECUADOR and VENEZUELA, respectively renamed SANTA OLIVIA and SANTA ISABEL took the place of these two on the secondary South American service EL SALVADOR was renamed SANTA ANA and GUATEMALA , SANTA CECILIA. The previous SANTA CECILIA had been sold to Norway.
Late in 1932 he depression forced the suspension of the secondary service and SANTA ISABEL, SNTA INEZ, SANTA OLIVIA & SANTA RITA were tied up. This service was, however, resumed the following year.
To comply with its mail contracts, Grace had agreed to build four new ships. These the SANTA ROSA class were ordered from Federal Shipbuilding Co. Kearney, New Jersey and delivered in 1932-1933. They were designed by William Francis Gibbs, who had also drawn plans of Matson’s MALOLO and later to draw those of the AMERICA and the record-breaker UNITED STATES.
These ships had some general resemblance to MALOLO, with her great beam and low stern. Their original gross tonnage of 11,200 was later reduced to 9,100 by the cutting of tonnage openings in # 6 shelter deck. Subsequently their tonnage was again changed, all of which reduced tonnage dues and Panama Canal tolls. Their overall length was 508 ft. and beam 72 ft.
Their power plants were at the time second to none in efficiency. Each of the water tube steam generators with a pressure of 430 lbs. produced 6000 hp. and each ship could make 18-1/2 knots with only three boilers active. The main engines were double reduction turbines. The screws turned inward, and for this reason were very awkward to maneuver. The passenger capacity of the SANTA ROSA class was 209 in first class and about 50 in steerage. Their public rooms were all on the promenade deck, with the dining salon extending two and a half decks in height to a roll back dome. The after dining room bulkhead was adorned with a large oil painting of a Grace clipper. Each cabin, whether single or double was equipped with private bath.
With the new quartet the Grace Line established the first passenger service between New York and Seattle. Calls were made at Havana, Puerto Colombia, Cartagena, Canal Zone, Punta Arenas, La Libertad, San Jose, Mazatlan, Los Angeles, San Francisco and Victoria. The first ship the SANTA ROSA sailed November 26, 1932; the last, SANTA ELENA, April 4, 1933. New York- Seattle running time was 20 days, including one day in Los Angeles and two in San Francisco. Average speed 18-1/2 knots. Before the New York sailing, each ship called at Philadelphia for cargo only.
In 1934 the port time in New York was greatly reduced and the call at Philadelphia eliminated. The time saved enabled the ships to make a shuttle run between Seattle and San Francisco. The 20-knot service and the ship’s superior accommodations to anything the Pacific Coast shipping had to offer made this an exceedingly popular run.
It was not long before other companies complained that, since Grace ships were subsidized for foreign trade they should not compete in the coastwise business. By the end of 1934 Seattle ceased to be a port of call and the voyage ended in San Francisco. Since three ships could now maintain the service, the SANTA LUCIA was reassigned to the South American run. Late in 1936 Grace acquired the Red D Line and it’s Caribbean Service, and early in 1937 SANTA ROSA, SANTA PAULA and SANTA ELENA entered that service: New York to Venezuela, Curacao, Colombia, Cristobal and Haiti.
In addition to the services already mentioned, Grace operated several cargo runs, for which it built eight 12-knot freighters, between 1913 and 1919. These were all of about 10,000 deadweight tons. They were the SANTA CATALINA, SANTA CECILIA and the six already mentioned as running inter-coastal in the early 1920’s. There was also a 13,000 ton tanker NORA, named for the daughter of J.P. Grace. all these freighters had been sold by 1925 and the tanker was disposed of in 1932. SANTA CATALINA by 1919 had become the USS BLACK HAWK, a destroyer tender.
Early in 1936 Grace sold SANTA CECILIA (ex SANTA ANA) and SANTA TERESA to the Merchants & Miners Transportation Company, SANTA ELISA, SANTA ANA (ex SANTA LUISA) went to the Alaska Steamship Company. SANTA INEZ and SANTA RITA were bought by the Navy in 1940 and the SANTA BARBARA and SANTA MARIA also in 1940. SANTA OLIVIA and SANTA ISABEL were also sold.
The Navy took over the SANTA LUCIA in 1942 ; as the USS LEEDSTOWN, she was sunk in the North African invasion. The SANTA ELENA was sunk the following year off the Philippville on the Algerian coast. SANTA CLARA as the SUSAN B. ANTHONY went down in the Normandy invasion.
Of the ships built before 1939 only the SANTA ROSA and SANTA PAULA survived. They continued to be the flagships of the fleet until 1958 when they were replaced by sister ships of the same name.
The Government had six uncompleted C2 type hulls and these were offered to Grace Line. Grace Line accepted the offer and had them converted to 52 passenger vessels. These “combos” became very popular and were a huge success and Grace Line had three more built. The first six were fitted out to carry bananas from Ecuador to New York. The last three were to be on the Caribbean run and were not equipped to carry bananas. Graces postwar fleet consisted of the nine combos, the Santa Rosa and Santa Paula, (which had been returned to Grace Line and refitted again to the liners that they once were) and nine C2 freighters. The Santa Rosa and Santa Paula served the Caribbean calling at Curacao, La Guaira, Aruba, Kingston, Port au Prince and Port Everglades, sailing from New York every two weeks. The three Caribbean “combos” called at Santo Domingo, Puerto Cabello, La Guaira, Maracaibo, Barranquilla, Cartagena, Baltimore, Philadelphia and New York. The other six “combos” along with the C2 Freighters sailed from New York to the West Coast of South America as far as Valparaiso.
In 1956 Grace decided to replace the Santa Rosa and Santa Paula with two new vessels. The new vessels a Gibbs & Cox design were to be called Santa Rosa and Santa Paula. They were 15,000 gross tons and 584 feet overall with an 84 foot beam. The first vessel the Santa Rosa was delivered in 1958. and the second Santa Paula soon followed. At this time cargo costs were escalating and cargo offerings to Venezuelan ports were declining and Grace decided that with the Santa Rosa and Santa Paula and two freighters being converted to all container vessels would meet the requirements in the Caribbean. The Santa Eliana and Santa Leonor two C2 type vessels were converted to all container vessels. These were the first American container vessels in foreign trade. The converted Santa Eliana sailed for Venezuela January 1960 with 176 containers containing powdered milk and other general cargoes. The longshoremen refused to unload the containers even though some sort of a previous agreement had been made by the agency. After 18 days an agreement was reached and the Santa Eliana was unloaded with the provision that no more vessels of this type would be used. The sailing of the Santa Leonor was canceled and both vessels were laid up.
In 1959 The Saint Lawrence Seaway opened and Grace obtained approval for an operational subsidy for the Great Lakes route. The route would serve ports on the Great Lakes to Cuba, Haiti, Dominican Republic, Barbados and ports on the north coast of Venezuela and Colombia. The decision to operate to the Great Lakes proved to be a financial disaster for Grace and the run was given up after one season.
In 1960 Grace Line decided to replace the aging “Combos” with four new 20 knot passenger vessels to carry approximately 100 passengers. These vessels were to serve the west coast of South America. They were 20,000 displacement tons 546 feet long with a 79 foot beam. The names were chosen to honor the four countries, Panama, Colombia, Ecuador & Peru They were designed with all new advanced cargo carrying devices. Each was fitted out to carry 360,000 cubic feet of bananas (90,000 stems approx. 4000 tons) in three holds, on the southbound voyage these areas were used for carrying autos or palletized cargoes which were loaded by a special pallet handling system. There were 5 cargo elevators in 3 holds. The other two holds were container holds. There were four gantry cranes on deck which when married in pairs could handle 40 foot containers. Container capacity was 175 twenty-foot containers. The four “M” ships, as they were called carried 125 first class passengers. Public rooms were spacious and tastefully decorated and there was a large outside tiled swimming pool.
About this time Grace decided to replace the aging freighters and six new freighters were built, the first of these was the Santa Lucia and these ships became known as the “L” ships. They were modern vessels with refrigerated compartments for Chilean fruit and Ecuadorian bananas. They were equipped for 12 passengers in luxurious staterooms and had seven hatches with 10-ton booms and two 30-ton booms and a 80 ton jumbo boom.
Things were normal until 1969 when the parent company W.R. Grace decided to go out of the steamship business and concentrate on chemical and other company ventures. Grace Line was sold to Prudential Line, a small line owned by Skouras of 20th Century Fox. At first the line was called Prudential Grace Lines and later the Grace was dropped and it became just Prudential Line. The ships were operated as before with most of the same personnel aboard but in 1970 Prudential decided to suspend the Caribbean service and the Santa Rosa and Santa Paula were laid up, never to sail under the American Flag again. The “M” ships were sailed as freighters until 1972 when three were transferred to the west coast. They were once again returned to passenger ship status. They sailed from San Francisco, north to Tacoma and Vancouver thence through the Panama Canal calling at ports on the east coast of South America then through the Strait of Magellan to call at ports on the west coast of South America and thence return to Los Angeles and San Francisco. This was a 59-day voyage. The Santa Magdalena remained on the east coast until 1974 when she too was transferred to the west coast to sail with the other three.
In 1978 the Prudential Line was taken over by Delta Lines, In 1983 there was a sharp drop in cargo bookings to South America and operations began to wind down. The six “L” class freighters were laid up and finally sold. The four “M” ships continued to run until 1984 when all operation of the former Grace Line Santas ceased.
At its peak, the Grace Line was a major force in American merchant shipping. Shortly after World War II it owned 23 ships totaling 188,000 gross tons, plus 14 more on bareboat charters.